Hoshizaki KM-650MAH Manuale Utente

Hoshizaki “A Superior Degree of Reliability” www.hoshizaki.com Models KM-650MAH KM-650MWH KM-650MRH Modular Crescent Cuber Hoshizaki America, Inc. I

103. KM-650MRHUnit: mm (in.)

11II. Installation and Operating Instructions WARNING1. This icemaker must be installed in accordance with applicable national, state, and local regul

12C. LocationCAUTION1. This icemaker is not intended for outdoor use. Normal operating ambient temperature should be within 45°F to 100°F (7°C to 38°C

13E. Electrical Connection WARNINGFor All Models1. Electrical connection must be hard-wired and must meet national, state, and local electrical code r

14F. Installation of Remote Condenser Unit WARNING1. Installation of remote condenser unit must be performed by properly trained and certied service

153. Setup1) Secure the legs to the remote condenser unit with the 8 bolts and nuts provided. See Fig. 6.2) The legs have 8 mounting holes. Secure the

16e. Mark a reference line on the female coupling and the remote condenser unit or icemaker panel. Using a backup wrench on the back of the female cou

176) Evacuate through the Schrader access ports on the Parker quick connect couplings and charge with R-404A refrigerant vapor to a pressure of 15 to

185. Line Set Exceeding 66 FeetCAUTIONThe icemaker, line set, and remote condenser unit must contain the same type of refrigerant. Mixing of refrigera

192) Remove the junction box cover on the remote condenser unit. Remove the fan motor junction box cover on the icemaker.3) Install a ground wire from

2IMPORTANTOnly qualied service technicians should install, service, or maintain this icemaker. No installation, service, or maintenance should be und

20G. Water Supply and Drain ConnectionsSee Fig. 12, 13, or 14 WARNING1. Water supply and drain connections must be installed in accordance with applic

211. Icemaker•Icemakerwatersupplyinletis1/2"femalepipethread(FPT).Aminimumof3/8"ODcopper tubing is recommended for the icema

222. Water-Cooled Condensera) Connection to an Open Drain System•Condenserwatersupplyinletis1/2"femalepipethread(FPT).Aminimumof3/8

23b) Connection to a Closed Loop System•Condenserwatersupplyinletis1/2"femalepipethread(FPT).Aminimumof3/8"ODcopper tubing i

24H. Final Checklist WARNINGCHOKING HAZARD: Ensure all components, fasteners, and thumbscrews are securely in place after installation. Make sure that

25I. Startup WARNING1. All parts are factory-adjusted. Improper adjustments may adversely affect safety, performance, component life, and warranty cov

26III. Cleaning and Maintenance WARNINGCHOKING HAZARD: Ensure all components, fasteners, and thumbscrews are securely in place after any cleaning or m

271. Cleaning Procedure1)Dilute16.oz.(473ml)ofHoshizaki"ScaleAway"with3gal.(11l)ofwarmwater.2) Remove all ice from the ev

2822) Replace the front panel in its correct position.23) Turn on the power supply to rinse off the cleaning solution.24) Turn off the power supply af

29B. MaintenanceThis icemaker must be maintained individually, referring to the instruction manual and labels provided with the icemaker. WARNING1. On

3CONTENTSImportant Safety Information ... 4I. Specicati

30C. Preparing the Icemaker for Long StorageCAUTION1. When storing the icemaker for an extended time or in sub-freezing temperatures, follow the instr

315) Open the water regulating valve by using a screwdriver to pry up on the spring retainer underneath the spring. While holding the valve open, blow

32HOSHIZAKI AMERICA, INC. 618 Hwy. 74 S., Peachtree City, GA 30269 USA TEL (770) 487-2331 FAX (770) 487-3360 www.hoshizaki.com 91A1KN10C

4Important Safety InformationThroughout this manual, notices appear to bring your attention to situations which could result in death, serious injury,

5MOTOR-COMPRESSOR THERMALLY PROTECTED, NOT INTENDED FOR OUTDOOR USE!Hoshizaki America, Inc.Peachtree City, GAwww.hoshizaki.comICE MAKER WITHOUT STORAG

6MOTOR-COMPRESSOR THERMALLY PROTECTED, NOT INTENDED FOR OUTDOOR USE!Hoshizaki America, Inc.Peachtree City, GAwww.hoshizaki.comICE MAKER WITHOUT STORAG

7MOTOR-COMPRESSOR THERMALLY PROTECTED, NOT INTENDED FOR OUTDOOR USE!Hoshizaki America, Inc.Peachtree City, GAwww.hoshizaki.comICE MAKER WITHOUT STORAG

8Unit: mm (in.)B. Dimensions / Connections1. KM-650MAH

92. KM-650MWHUnit: mm (in.)